GekkoBox - Filled BOX plus ?

We will build a 'Wohnkabine' (living box) to fit your provided truck. We can build it onto the existing rear frame, or also provide the metal support frame which the GFK/GRP Wohnkabine is bolted to, and in-turn this frame is bolted to the truck chassis - if  the truck has a torsionally flexible chassis such as  Unimog or Steyr, then the frame will be attached with a 3 or 4 point linkage OR using an 8 spring-bolt connected arrangement. If necessary, we can build container twist-lock corners into the frame, which then allows the living cabin to be lifted between different vehicles.

 

We can build a box according to your required size, although typically customers choose between 3.7m (for Unimog) and 8m (for 3 or 4 axle trucks) long box, width between 2 and 2.4m, and heights up to 2.3m. We can also provide variations to the standard box format, such as; opening roofs (pop-up & hinged), square, angled or curved front/rears etc

 

We construct the walls in our own workshop, and therefore can vary the thickness and proportion of insulation/wood - our 'standard thickness' of wall is 50mm, with common increases available to 60, 80 or even 100mm.

The following main features are included:

 

Gekkobox - Filled Boxes
  Item Box 1 Box 2 Box 3 Box 4
           
  Box size (length, m) 3.8m box 5m box 6m box 7 to 8m
  Base vehicle        
1          
2 Wheel base /vehicle length (mm)        
3 Maximum/Empty/Load weights (kg)        
4 Engine size, power (kw with/without turbo)        
5 Torque/ (effective with lowest gearing)        
6 Gears - 4 High, 4 Low (reverse on all low gears)        
7 Ground clearance (with 12.5 tyres), mm        
8 Maximum entry angle        
9 Escape (Departure) angle        
10 Maximum gradient, %        
11 Maximum side slope, degrees        
12 Preparation for 4WD or diff locks        
13 Wading depth (Recommended, Limit) m        
14 Preparation before/after wading        
15 Off-road ability        
16 Max speed (km/h)        
17 Fuel consumption        
18 Suspension - coil spring (30 degree opposite twist)        
19 Frame twist (degrees)        
20 Working of diff locks, front, back and between axles        
21 Fuel pre and main filters        
22 Hi drivers cab (Unimog)        
23 Trailor hitch (Ringfelder etc.)        
24  'Fast Axles'        
Base vehicle additions
25 Turbo fitted (if not available on standard unit)        
26 Intercooler kit fitted        
27 High speed Overdrive (if no PTO required)        
28 Larger tyres (14.5x20) Optional Optional Optional Optional
29 2 spare wheels or tyres Optional Optional Optional Optional
30 Renovated/painted chassis Optional Optional Optional Optional
31 Renovated (exterior)/painted drivers cab Optional Optional Optional Optional
32 Long range diesel tanks (400+ litres) Optional Optional Optional Optional
           
33 Tyre pressure adjustment system Optional Optional Optional Optional
34 Tyre-wheel winch (custom, electric) Optional Optional Optional Optional
35 Motorbike or bicycle rack Optional Optional Optional Optional
36 Snorkel fitted (if missing) Optional Optional Optional Optional
37 Front under-engine protection plate Optional Optional Optional Optional
38 Uprated alternator (100 amps) Optional Optional Optional Optional
39 Second alternator (not with mechanical A/C) Optional Optional Optional Optional
40 Second vehicle battery (reserve start plus winch) plus custom Aluminium box enclosure Optional Optional Optional Optional
41 Custom chequer-plate battery box (lockable) Optional Optional Optional Optional
42 Cut-off / isolation switches to both 'vehicle'  batteries (German army spec) Optional Optional Optional Optional
43 Truck double tone air horn Optional Optional Optional Optional
44 Chassis mounted army style jerry can holders Optional Optional Optional Optional
45 Custom made external storage boxes Optional Optional Optional Optional
46 External roof mounted large storage locker Optional Optional Optional Optional
47 Full roof rack (with branch guard) Optional Optional Optional Optional
48 12v on roof rack ? Optional Optional Optional Optional
49 Customised/adapted roof track (i.e. to support a canoe etc.) Optional Optional Optional Optional
50 Tilt meter Optional Optional Optional Optional
51 Satellite navigation Optional Optional Optional Optional
52 Searchlight Optional Optional Optional Optional
53 Mechanical Air Conditioning (only whilst driving - mainly for drivers cab) Optional Optional Optional Optional
54 Electrical air conditioning (drivers cab) Optional Optional Optional Optional
55 Compressed air line        
56 230v generator platform Optional Optional Optional Optional
57 230V generator (or 110v ) Optional Optional Optional Optional
58a Radio/DVD/reversing display (in drivers cab) (reversing camera below) Optional Optional Optional Optional
58b 4-view camera system (including night vision) Optional Optional Optional Optional
59 Additional wide angle rear view mirror Optional Optional Optional Optional
60 Kerbside mirror Optional Optional Optional Optional
61 Renovated drivers cab (interior)        
62 Custom between seats storage unit Optional Optional Optional Optional
63 ISRI driver/co-driver mechanical sprung seats Optional Optional Optional Optional
64 ISRI driver/co-driver air sprung seats Optional Optional Optional Optional
65 KAB or re-conditioned air-sprung seats Optional Optional Optional Optional
66 Additional individual seats in rear of front cab Optional Optional Optional Optional
67 Thermal insulation in drivers cab Optional Optional Optional Optional
68 Under bonnet sound proofing Optional Optional Optional Optional
69 Drivers Cab sound proofing kit Optional Optional Optional Optional
70 Standheizung' in drivers cab Optional Optional Optional Optional
71 Uprated rear springs (Unimog)        
72 Additional rear stabiliser (Unimog)        
73 Front waist lights (Unimog)        
74 Additional truck forward lighting (high mounted) Optional Optional Optional Optional
75 Headlight Light protection grills Optional Optional Optional Optional
76 12 tonne electric winch (front) - some model 4's may have mechanical or hydraulic rear winch from base vehicle Optional Optional Optional Optional
77 Electric winch (rear) - some model 4's may have mechanical or hydraulic rear winch from base vehicle Optional Optional Optional Optional
78 Additional pre-filter Optional Optional Optional Optional
           
           
Vehicle Winterisation options
79 Engine block heater (110 or 230v) - pre-start assistance in  cold temperatures        
80a Pre-start engine coolant warming system (110 or 230v) Optional Optional Optional Optional
80b Pre-start engine coolant warming system (diesel) Optional Optional Optional Optional
81 Oil pan heater (12v or 110v/230v or both) Optional Optional Optional Optional
82 Battery heater (12v or 110v/230v or both) Optional Optional Optional Optional
83 Diesel filter heater (12 or 24v) for pre-start and for driving assistance        
84 Diesel tanks heater (12v or 230v) for pre-start Optional Optional Optional Optional
85 In-line diesel fuel heater (engine coolant) for driving assistance Optional Optional Optional Optional
86 Heated fuel line (12 or 24v ) for pre-start or driving  assistance Optional Optional Optional Optional
87 Water tank heaters or  Truma Eis-ex gas regulator 12v heater Optional Optional Optional Optional
88 Couplertec Anti-corrosion system fitted ? Optional Optional Optional Optional
Living Box features
89 Empty cabin, Inner dimensions (WxLxH) metres above above above above
90 Living box size xyz        
91 Self-supporting composite wall construction of between 48 and 60 mm 50mm 50mm 60mm 60mm
92 Thicker walls (60mm), standard 48mm Optional Optional Optional Optional
93 Thicker walls (100mm), standard 48mm Optional Optional Optional Optional
94 Flexible walled tunnel with closing door Optional Optional Optional Optional
95 2nd tunnel closing door Optional Optional Optional Optional
96 Frame - 3 point attachment        
97 Chunky Resin based edging/corners supplemented by aluminium checkerplate sheeting Optional Optional Optional Optional
98 Roof top/edge protections rails fitted Optional Optional Optional Optional
99 Roof terrace fitted Optional Optional Optional Optional
100 12v/230v available on roof terrace Optional Optional Optional Optional
101 Length of single beds (cm) various various various various
102 Width of single beds (cm) various various various various
103 n/a        
104 Beds  with 1 double converting from sofa (choice of covering fabric) 2+2 2+2 4+2 4+2
105 Width of double bed(s) (cm) various various various various
106 Custom beds (rear usually form table base), inter-changing with living room sofas
107 Additional seat-belted seats in rear living cabin
  n/a        
108 270 degree awning plus LED lighting
           
109 3 burner hob and oven (gas)
110 3 burner hob (diesel) Optional Optional Optional Optional
111 Electric induction hob (requires larger inverter & 2 batteries) Optional Optional Optional Optional
112 Extra slide-out kitchen work surface fitted Optional Optional Optional Optional
113 Large 3-way fridge (gas, 12v, 230v)
114 Engel Freezer (12v, 230v) - 40 litre Optional Optional Optional Optional
115 Custom entrance ladder (Zinc'ed-steel or Aluminium) Optional Optional Optional Optional
116 Internal shower and basin
117 External shower (1 or 2 sides)
118 Standard water filter
119 Water filtration system (various) Optional Optional Optional Optional
120 Sureflow water pump (standby included in 'spares')
121a Gas or diesel fired grill/oven
121b Gimbles for Wallas Diesel oven Optional Optional Optional Optional
122 Microwave or Combi-Microwave (with grill) Optional Optional Optional Optional
123 External gas socket
124 12v extractor in bathroom and kitchen area
125 Main  fusebox/controller with level gauges, voltmeter etc.
126 Generous fitting of 12v, 230v and USB sockets in front and rear cabins
127 TV-DVD player Optional Optional Optional Optional
128 Satellite TV receiver & dish Optional Optional Optional Optional
129 4-way speakers in living cabin Optional Optional Optional Optional
130 Living cabin speakers (connected to drivers cab sound system) Optional Optional Optional Optional
131 Living Cabin (Separate from driving cab)  Sound system Optional Optional Optional Optional
132 Sandramp holders
           
133 Large opening 'panoramic' window panel
134 3 side windows, 2 roof windows 4 side, 3 roof 4 side, 3 roof 4 side, 3 roof
135 Real glass side windows (Outbound or KCT) Optional Optional Optional Optional
136 Real glass roof windows (NOT shower-room) Optional Optional Optional Optional
137 Additional windows (e.g forward facing)        
138 Light strips around roof windows
139 Number of external access doors        
140 Airline style'  loading/attachment strips
141 Entrance door with lowered/recessed handle
142 Hardened entrance door (with 3 locks)
143 High & low cupboards in kitchen, bedroom, bathroom areas with choice of colour (constructed in 8mm plywood, plus steel frames for seating) including wardrobe and choice of doors/shelves versus bins, with aluminium edging
144 Heavier plywoord used in internal construction Optional Optional Optional Optional
145 Standheizung' in living cab (failover) Optional Optional Optional Optional
146 Calorifier (marine spec) Optional Optional Optional Optional
147 Electric floor heating fitted Optional Optional Optional Optional
148 Heating/drying radiator Optional Optional Optional Optional
149 Truma Gas radiator X Optional Optional Optional
150 Electrical air conditioning (living box) Optional Optional Optional Optional
151 Fresh water tanks 400l 400l 400l
152 Additional fresh water tanks Optional Optional Optional Optional
153 Grey water tank (60 litre) 150l 150l 150l
154 12v Macerator porcelain toilet (100 litre tank)
155 Cassette toilet Optional Optional Optional Optional
156a Size of black water tank ? (only with macerator) 60 100 100 100
156b Black water rinsing from Grey water tank Optional Optional Optional Optional
157 Composting system (Max 2 adults usuage) Optional Optional Optional Optional
158 Solar charging with regulator 200W 400W 600W 600W
159 Additional Solar panels Optional Optional Optional Optional
160 Wind generator fitted/supplied Optional Optional Optional Optional
161 AGM 200 A hr batteries 1 2 3 4
162 Additional batteries Optional Optional Optional Optional
163 12v to 230v converter (to 2kw), Victron or Mastervolt 3kW 3kW
164 Increase inverter rating (to 5kw), Victron or Mastervolt Optional Optional Optional Optional
165a 230v battery charger
165b Additional 110v to 230v transformer (for US and other countries operation) Optional Optional Optional Optional
166 Vented/separated chamber for 1 11 kg propane gas bottle with piping, access etc.
167 Additional gas bottles Optional Optional Optional Optional
168 Burglar alarm Optional Optional Optional Optional
169 Side/rear/front floodlights Optional Optional Optional Optional
170 External entrance lights (LED's) Optional Optional Optional Optional
171 Safety deposit box Optional Optional Optional Optional
Additional Internal Options
172 Washing machine or dishwasher Optional Optional Optional Optional
173 12v vacuum cleaner Optional Optional Optional Optional
174 Crockery & cups/glasses 'organisers' Optional Optional Optional Optional

Wo sind wir  / How to find us?

Gekkotruck GmbH
Untere Römerstr. 14
94527 Aholming

Germany

Kontakt/Contact

Email us on sales@gekkotruck.de (or +49 (0)173 8466344)

Druckversion Druckversion | Sitemap
© Gekkotruck version 1.6 (23 May 2016)